PARTS LIST INCLUDED Frymaster, a member of the Commercial Food Equipment Service Association, recommends using CFESA Certified Technicians. 24-Hour
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-2 2.2 General Qualified, licensed, and/or authorized installation or servic
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-3 2.3 Principles of Operation The incoming gas flows through orifices and i
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-4 2.5 Pre-Installation (cont.) B. Clearances: The fryer area must be kept
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-5 2.6 Air Supply and Ventilation DANGER This appliance must be installed w
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-1 3.1 Installing the Fryer Decathlon 65 Series fryer systems are shipped in sections.
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-2 3.1 Installing the Fryer (cont.) 3. Connect red/white or red/yellow wires (Figure
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-3 3.1 Installing the Fryer (cont.) 9. Install the front connecting post on the conn
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-4 3.1 Installing the Fryer (cont.) DANGER Fryers must be at room temperature and em
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-5 3.2 Gas Connections (cont.) DANGER If gas odors are detected, the gas supply MUST
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-6 3.2 Gas Connections (cont.) C. Manual shut-off valve: This gas service supplier-i
Please read all sections of this manual and retain for future reference. NOTICE This appliance is intended for professional use only and is to be op
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-7 3.2 Gas Connections (cont.) I. Flexible Couplings, Connectors and Casters: 1.
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-8 3.3.1 Specifications 3.3.1.1 Adjustments to Different Gas Types Gas Adjustments
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 3: INSTALLATION 3-9 3.3.2 Gas Conversion Procedures (cont.) Contact factory with the following informa
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-1 4.1 Initial Start-up WARNING The on-site supervisor is responsible for ensurin
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-2 4.1.1 Pilot Lighting Procedures, Electronic Ignition Systems Initial Pilot Lig
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-3 4.2 Boil-Out Procedure DANGER Never leave the fryer unattended during the boi
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-4 4.2 Boil-Out Procedure (cont.) G. The burners will heat the boil-out solution
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 4: FRYER OPERATIONS 4-5 4.3 Final Preparation WARNING NEVER set a complete block of solid shortening
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-1 WARNING Drawings and photos used in this manual are intended to illustrate
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-2 5.2.1 Assembling the Filter (cont.) Assemble the filter as follows: 1. R
DANGER Improper installation, adjustment, maintenance or service, and unauthorized alterations or modifications can cause property damage, injury, o
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-3 5.2.1 Assembling the Filter (cont.) 4. Place the crumb tray in filter pan
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-4 5.2.2 Disassembling/Assembling and Cleaning an Optional Filter Leaf Follow
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-5 Cleaning the Filter Leaf Assembly Clean the two seal frame pieces, screens
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-6 5.3.2 Filtering Tools Assemble tools to be used for filtering. These are
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-7 5.4 Operating the Filter 5.4.1 Filter Operation CAUTION NEVER operate t
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-8 5.4.1 Filter Operation (cont.) 4. When all the oil has drained from the f
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-9 5.4.1 Filter Operation (cont.) 8. Begin the filtering process by pulling
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-10 5.4.1 Filter Operation (cont.) 11. After all shortening is pumped back i
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 5: FILTRATION OPERATION 5-11 5.4.1 Filter Operation (cont.) 14. OPTIONAL EQUIPMENT: Drain-flushes are
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 6: PREVENTATIVE MAINTENANCE 6-1 6.1 General DANGER Never attempt to clean the fryer during the cookin
FPD65 Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS Page # 1. INTRODUCTION 1-1 1.1 After Purchase 1-1 1.2
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 6: PREVENTATIVE MAINTENANCE 6-2 6.1.3 Periodic/ Annual The fryer should be inspected and adjusted peri
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 6: PREVENTATIVE MAINTENANCE 6-3 6.1.3 Periodic/ Annual (cont.) • Check filtration system integrity as
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-1 7.1 General DANGER Hot cooking oil/shortening will cause severe burns. Never a
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-2 7.2 Pilot Burner Malfunction (cont.) 3. Check all connections for cleanliness
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-3 7.3 Main Burner Malfunctions (cont.) D. Fryer will not reach the temperature
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-4 7.4 Wiring Diagram, Main HI LIMITTO J2 COMPUTER INTERFACE BOARDSPEAKERSOUNDGRD
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 7: TROUBLESHOOTING 7-5 7.5 Wiring Diagram, Filter 31C82C35C35C86C33C33C82CP2T5T4T230C27C8C9C120V12CCI
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-1 8.1 Cabinetry and Related Components 21347658910121314151617181920211122232425Typic
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-2 8.1 Cabinetry and Related Components (cont.) ITEM PART # COMPONENT 1 810-0357 C
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-3 8.2 Doors, Topcaps and Related Components 21345678910111213FPD665 Shown ITEM PAR
FPD65 Series Gas Fryers Installation & Operation Manual TABLE OF CONTENTS (CONT.) Page # 5. FILTRATION OPERATION 5-1 5.1 General
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-4 8.3 Frypots, Burners and Related Components 16201235418678159101112131421281719222
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-5 8.3 Frypots, Burners and Related Components (cont.) ITEM PART # COMPONENT 1 823-
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-6 8.4 Component Box Components 1CM4-S23456789101112131415161817 ITEM PART # COMPON
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-7 8.5 Filter Pan and Related Components 1234781011956121314 ITEM PART # COMPONENT
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-8 8.6 Oil-Drain Components 6573121517181920212223169Typical Drain Components(FPD665 S
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-9 8.6 Oil-Drain Components (cont.) ITEM PART # COMPONENT 1 823-4189 Pipe, Drain- R
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-10 8.7 Oil-Return Components Oil Disposal Plumbing(Optional)1456891011121314157232221
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-11 8.7 Oil-Return Components (cont.) ITEM PART # COMPONENT 3 813-0173 Union, ½&qu
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 8: PARTS LIST 8-12 8.8 Suction Tube, Oil-Return Components (cont.) ITEM PART # COMPONENT 1 810-0697
THIS PAGE INTENTIONALLY LEFT BLANK
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-1 1.1 After Purchase In order to improve service, have the following chart filled in
Frymaster, 8700 Line Avenue, Shreveport, Louisiana 71106 TEL 1-318-865-1711 FAX (Parts) 1-318-688-2200 FAX (Tech Support) 1-318-219-7135 PRINTED
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-2 1.4 Computer Information (cont.) The user is cautioned that any changes or modific
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 1: INTRODUCTION 1-3 1.6 Service Personnel 1.6.1 Definitions A. Qualified and/or Authorized Operatin
FRYMASTER FPD65 SERIES GAS FRYERS CHAPTER 2: IMPORTANT INFORMATION 2-1 2.1 Receiving and Unpacking Equipment A. Check that the containers are up
Kommentare zu diesen Handbüchern